T214 Bonny Won't Start

Discussion in 'Technical Help' started by Wayne miles, Apr 1, 2019.

  1. Wayne miles

    Wayne miles New Member

    Joined:
    Mar 29, 2019
    Messages:
    1
    Likes Received:
    0
    Trophy Points:
    1
    Location:
    Hampshire
    I took my 2016 T214 Bonny off trickle charge, switched the ignition key and everything lit up ok, I then went to start it and it just all went dead?
    would it have blown a fuse?
     
    #1
  2. Vulpes

    Vulpes Confused Member

    Joined:
    Mar 14, 2018
    Messages:
    10,240
    Likes Received:
    19,494
    Trophy Points:
    1,000
    Location:
    Netherlands
    Hi and welcome.
     
    #2
  3. Sprinter

    Sprinter Kinigit

    Joined:
    Aug 17, 2014
    Messages:
    7,362
    Likes Received:
    5,995
    Trophy Points:
    1,000
    Location:
    uk
    Starting System Symptoms:

    Weak battery symptoms:
    -- Slow cranking.
    -- Stops cranking suddenly on compression stroke with button pressed.
    -- Starts when starter button is released at end of cranking.
    Repair:
    -- Charge/Test/Replace battery.
    Failure Modes:
    -- Loss of capacity. Appears to charge, voltage good but no reserve for starting.
    -- Won't hold a charge.
    -- Low voltage/cell failure.
    Preventative Maintenance:
    -- Check fluid levels regularly
    -- Maintain full charge: Regular riding, trickle charger.

    Ignition Coil failure symptoms:
    -- Hard starting/misfiring during cranking.
    -- Rough idle that can't be tuned out with carb adjustments and carb cleaning.
    -- Idle misfire clears with new sparkplugs, returns in a few hundred miles
    Repair:
    -- Replace: Preferably with Nology for higher reliability than stock Gill coils.
    Failure Mode:
    -- Shorted turns in secondary resulting in weak spark.
    Preventative Maintenance:
    -- None
    Testing:

    Pickup Coil failure symptoms:
    -- No spark at all
    -- Spark quits with engine hot, returns when engine cool.
    -- Note: Pickup coil failure is total. There is no random misfire spark loss.
    Repair:
    -- Replace pickup coil
    Failure mode:
    -- Thermal intermittant with long (15-30 minute) period.
    Preventative Maintenance:
    -- None. Get a spare.
    Testing:
    -- Ohms checks hot and cold.

    Worn starter symptoms:
    -- Sometimes won't crank until the bike is rocked in gear.
    -- Excessively noisy cranking with a grinding sound.
    -- Click from under seat but no cranking.
    Failure Mode:
    -- Brush wear progressing to commutator damage.
    -- Bearing failure related to brush wear.
    Repair:
    -- Rebuild or replace.
    Preventative Maintenance:
    -- Maintain battery in peak condition.
    -- Follow proper starting procedures. Neutral, clutch in.
    -- Crank 5-10 seconds at a time max., switch off for twice as long before cranking again.

    Worn sprag clutch symptoms:
    -- Very loud rattling when cranking
    -- Starter spins but engine doesn't turn
    Falure Mode:
    -- Breakage
    Repair:
    -- Replace sprag clutch
    Preventative Maintenance:
    -- Maintain battery in peak condition.
    -- Follow proper starting procedures. Neutral, clutch in.

    Worn starter solenoid:
    -- Click from under seat but no cranking.
    -- Won't crank after rocking bike.
    -- Starter continues to run after bike starts and won't stop until the battery is disconnected.
    Failure mode:
    -- Internal contact damage resulting in non-conduction.
    -- Internal contact damage resulting in contacts welding shut.
    -- Internal damage/wear prevents solenoid core movement.
    Preventative Maintenance:
    -- None.
    Repair:
    -- Replace starter solenoid.
    Testing:
    -- For no cranking, short across solenoid high-power terminals. Normal operation denotes failed solenoid contacts.


    ------------------
     
    #3
Loading...

Share This Page