995i wont start

Discussion in 'Technical Help' started by Dave Kirby, Aug 2, 2016.

  1. Dave Kirby

    Dave Kirby Member

    Jul 31, 2016
    4
    8
    Kent
    #1 Dave Kirby, Aug 2, 2016
    Last edited: Aug 7, 2016
    I have a 1999 Sprint 955i, and the bike started as normal, travelled 1 mile and the bike stalled. I couldn't restart her, engine turned over as normal, but battery drained very quickly,replaced battery with a brand new one after an overnight charge,I tried to start the bike the same thing happened again, this time I notice a strong smell of petrol, checked breather pipes and they were clear. That as far as i have got other then putting the battery on charge again........er help:confused:
     
  2. Dave Kirby

    Dave Kirby Member

    Jul 31, 2016
    4
    8
    Kent
    #2 Dave Kirby, Aug 7, 2016
    Update
    Found the fault to the brand new Halfords smart charger not charging the brand new battery I fitted :mad::mad:.Got a charger that works, Battery fully charge, bike starts, went for a ride, after a few miles, close throttle to slow down, engine dies, but all instruments lights are OK, engine will turn over but won't fire, no smell of petrol. Sat and waited for 20 mins bike starts
    carried on will ride. Same again happens, close throttle, engine dies etc etc. I eventually got home after breaking down a total of 4 times as described,the ride it self was great as long as I dont slow down to a crawl or close throttle.
    Any help please
     
  3. Tallulah

    Tallulah Member

    Dec 30, 2015
    32
    18
    County Durham
    #3 Tallulah, Aug 8, 2016
    this may seem really simple and patronising- but have done it myself as a qualified vehicle electrician and kicked myself repeatedly for not realising sooner.

    are the connections to your battery really tight ? if you check and they are not.. you don't have to share. (it took me two years to tell anyone when I did it.) the smell of petrol can be a false sign as that will happen when attempting to start repeatedly as the fuel will start being pushed round with any attempt to start.
     
  4. Dave Kirby

    Dave Kirby Member

    Jul 31, 2016
    4
    8
    Kent
    #4 Dave Kirby, Aug 8, 2016
    Hi Tallulah
    Thanks for the post, yep checked the tightness of the battery terminals,honest :), wondering if the installing and removing the battery has up set the ECU? and may need resetting any suggestions?
     
  5. Sprinter

    Sprinter Kinigit

    Aug 17, 2014
    5,993
    1,000
    uk
    #5 Sprinter, Aug 8, 2016
    is your engine management light on?
    what is your normal idle speed?
    check rectifier/regulator connections

    'it turned out to be the electrical connector block situated on the right hand side of the bike beside the fuel pump. This is on a sprint rs model, most of the small connectors have corroded away, therefore when i pulled the connector apart most of the spades fell out.'

    if its when hot it could be the crank position sensor

    side stand cut out switch? may be stand moved on the roundabout u spoke about
     
  6. Tallulah

    Tallulah Member

    Dec 30, 2015
    32
    18
    County Durham
    #6 Tallulah, Aug 10, 2016
    I think that I am in the same area as jtd now.. I am thinking that the connections to/from your fuel pump are rubbish. It won't upset your ecu - disconnecting your battery- once set, unless hit with a hammer/general depreciation, they are pretty fixed.
     
  7. Sprinter

    Sprinter Kinigit

    Aug 17, 2014
    5,993
    1,000
    uk
    #7 Sprinter, Aug 10, 2016
    do you hear any noises when you turn on?
     
  8. Dave Kirby

    Dave Kirby Member

    Jul 31, 2016
    4
    8
    Kent
    #8 Dave Kirby, Aug 10, 2016
    Thanks for your suggestions, unfortunately I will not be working on my bike until the weekend, will get back to you with my findings.
     
  9. Dave Kirby

    Dave Kirby Member

    Jul 31, 2016
    4
    8
    Kent
    #9 Dave Kirby, Aug 10, 2016
    yes a whine for a few seconds then stops but the whine returns and stays on
     
  10. Sprinter

    Sprinter Kinigit

    Aug 17, 2014
    5,993
    1,000
    uk
    #10 Sprinter, Aug 10, 2016
    the whine is the fuel pump it comes on to prime then should go off and wait for you to start her, it should not stay on.

    key on, couple of clicks, whine ,then press button ( no throttle )
     
Loading...
Similar Threads - 995i wont start
  1. Andy John

    Hi, my Daytona 995i(2006) wont start

    Andy John, Apr 13, 2015, in forum: Technical Help
    Replies:
    0
    Views:
    1,049
    Andy John
    Apr 13, 2015
  2. Malcolm Woods

    Triumph St995i

    Malcolm Woods, Sep 7, 2021, in forum: Triumph General Discussion
    Replies:
    5
    Views:
    844
    RobBr
    Sep 13, 2021
  3. decrepitus

    Wanted Sprint 995i

    decrepitus, Mar 11, 2020, in forum: Wanted
    Replies:
    2
    Views:
    757
    decrepitus
    Mar 11, 2020
  4. Mark Storey

    Trying To Find Luggage Racks For Older 995i.

    Mark Storey, Jan 3, 2020, in forum: Speed Triple
    Replies:
    1
    Views:
    763
    feckless
    Jan 8, 2020
  5. duncans

    cable driven speedo 995i tiger with spoked wheels

    duncans, Oct 12, 2016, in forum: Wanted
    Replies:
    0
    Views:
    648
    duncans
    Oct 12, 2016

Share This Page

Sign up