Tiger 800 Bloody Tiger Won't Start!

Discussion in 'Tiger / Explorer' started by steve lovatt, Aug 8, 2019.

  1. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #1 steve lovatt, Aug 8, 2019
    So after a successful, no issue 1500 mile tour, I tried to start the bike today only to be unexpectedly disappointed. :mad:

    The bike cranks but doesn't start - it just carries on spinning over without a hint that it will fire.

    Obviously kill switch is off, the needle does it's sweep and all the usual warning lights come on and I can hear the fuel pump priming. Charged up the battery and tried again 2 hours later but exactly the same. Spins away but bugger all happens.

    Any ideas?
     
    • Useful Useful x 1
  2. joe mc donald

    joe mc donald Joe
    Subscriber

    Dec 26, 2014
    16,061
    1,000
    slough / burnham
    #2 joe mc donald, Aug 8, 2019
    Steve Lovatt.
    You may have flooded the plugs. Perhaps take them out dry them of check for spark and go again. Also do check all the fuses.
    Regards
    Joe.
     
  3. Sprinter

    Sprinter Kinigit

    Aug 17, 2014
    5,995
    1,000
    uk
    #3 Sprinter, Aug 8, 2019
    Found this;-

    1/ One easy way to tell if it's the stepper, just crack the throttle open while you crank the bike. Give it some gas and if it fires and you can keep it running by working the throttle, it's likely your stepper motor.

    2/
    Checked the stepper motor. Seems clean enough, and moving on power on and during the fax machine noise. Gave it a bit of WD40 for good measure.

    Managed to get it started by holding the starter whilst winding the throttle open. Somewhere around 1/2 throttle it fired and caught. Since then it fires up straight away without any throttle. Took it for a test ride, stopped and started more than a dozen times and all seems fine.
     
    • Useful Useful x 1
  4. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #4 steve lovatt, Aug 8, 2019
    Thanks Joe, will check fuses but plugs are a pain to get at - tank has to come off!
     
  5. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #5 steve lovatt, Aug 8, 2019
    Cheers mate but I don't think the later (post 2015) Tigers have stepper motors. I could of course be wrong!
     
    • Like Like x 1
  6. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #6 steve lovatt, Aug 9, 2019
    Thinking about it now, all I did was wash it.
    Ungrateful b*stard! :mad:
    Won't be doing that again - be warned lads! :D
     
  7. crispey

    crispey crispey creme de la creme

    Nov 6, 2014
    7,331
    1,000
    Uk
    #7 crispey, Aug 9, 2019
    Blimey Steve that’s bad news. Could be water ingress somewhere, have a look in the clutch and side stand switch assembly, maybe do the paper clip jobbie
     
  8. thebiglad

    thebiglad Old fart, still riding !

    Sep 25, 2013
    5,072
    1,000
    Central France
    #8 thebiglad, Aug 9, 2019
    I might be wrong, but I don't think Steve eats paper clips :p:p
     
    • Funny Funny x 3
  9. crispey

    crispey crispey creme de la creme

    Nov 6, 2014
    7,331
    1,000
    Uk
    #9 crispey, Aug 9, 2019
    If it’s included in the full English he does!
     
    • Funny Funny x 3
  10. crispey

    crispey crispey creme de la creme

    Nov 6, 2014
    7,331
    1,000
    Uk
    #10 crispey, Aug 9, 2019
    @steve lovatt sorry mate, forgot the bike doesn’t turn over at all if the clutch switch is faulty
     
    • Like Like x 1
  11. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #11 steve lovatt, Aug 9, 2019
    Running again now! :):):)
    Not really sure why it wouldn't start or why it now does.

    Bloke on the Tiger Facebook page said his 2015 XC did it once and he just kept cranking until it fired up, has never had the problem since.

    Basically just tried that whilst opening the throttle a tad and it fired up and then instantly stalled. Did the same again and it caught first time and stayed running. Just got back from a quick "in between the showers" run and all seems fine. :)

    Thanks again for all the input (including the paper clips) :D
     
    • Like Like x 3
  12. crispey

    crispey crispey creme de la creme

    Nov 6, 2014
    7,331
    1,000
    Uk
    #12 crispey, Aug 9, 2019
    Probably water ingress somewhere then. Stick to jd
     
    • Agree Agree x 1
  13. steve lovatt

    steve lovatt Something else

    May 12, 2014
    9,242
    1,000
    North Yorkshire
    #13 steve lovatt, Aug 9, 2019
    Best to not wash it ever again then! :D:D
     
    • Agree Agree x 2
  14. dilligaf

    dilligaf Guest

    #14 dilligaf, Aug 9, 2019
    Get rid of the fecker :mad:
    Order one of these :cool: 39BB9670-ED32-46EB-8741-4FD222704E08.jpeg
     
    • Disagree Disagree x 1
    • Love You Love You x 1
  15. Tiglet

    Tiglet Vintage Member

    Mar 28, 2016
    4,434
    1,000
    Cheshire
    #15 Tiglet, Aug 9, 2019
    Dilli instead of telling peeps to order one of these,,,,,,

    upload_2019-8-9_15-56-24.jpeg
    Why don’t you order one yourself :p
     
    • Agree Agree x 1
  16. dilligaf

    dilligaf Guest

    #16 dilligaf, Aug 9, 2019
    I did :grinning: this is it :cool: 652942C9-326F-4BB1-80B2-86E4E11E5880.jpeg
     
    • Funny Funny x 1
  17. Tiglet

    Tiglet Vintage Member

    Mar 28, 2016
    4,434
    1,000
    Cheshire
    #17 Tiglet, Aug 9, 2019
    Well I won’t have guessed :laughing:

    Why haven’t you posted about your latest order on here :rolleyes::laughing::laughing:;):)
     
    • Funny Funny x 2
  18. dilligaf

    dilligaf Guest

    #18 dilligaf, Aug 9, 2019
    I will :)
    But I’m building up to it :p B83BA221-1B21-45AC-AC4B-95A10FC93D79.jpeg
     
    • Funny Funny x 2
Loading...
Similar Threads - Bloody Tiger Won't
  1. Malcolm Woods

    Bloody Cold

    Malcolm Woods, Apr 16, 2021, in forum: Lounge
    Replies:
    14
    Views:
    2,247
    Stramasher
    Apr 19, 2021
  2. Tricky-Dicky

    Bloody Toothache!

    Tricky-Dicky, Feb 14, 2021, in forum: Lounge
    Replies:
    30
    Views:
    4,424
    Metlhavens
    Nov 1, 2024
  3. Tricky-Dicky

    Bloody Scammers!

    Tricky-Dicky, Dec 9, 2020, in forum: Lounge
    Replies:
    9
    Views:
    2,385
    johne
    Nov 4, 2021
  4. Tricky-Dicky

    Bloody Speed Traps!!!

    Tricky-Dicky, Nov 6, 2020, in forum: Lounge
    Replies:
    49
    Views:
    7,098
    Pegscraper
    Nov 14, 2020
  5. Thripster

    Bloody Computers

    Thripster, Oct 22, 2020, in forum: Lounge
    Replies:
    16
    Views:
    1,858
    ChasChas
    Oct 22, 2020

Share This Page

Sign up